VW pasat 2002 esp problem *REŠENO*

zamenjen je abs
isti je bosch broj
pre kodiranja jedinice imao je sledece greske

Chassis Type: 3B - VW Passat B5
Scan: 01 02 03 08 15 16 17 19 35 36 37 46 47 55 56 57 58 75 76 77


VIN: WVWZZZ3BZ2P902651 Mileage: 200430km/124541miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: 038-906-019-AVF.lbl
Part No: 038 906 019 EP
Component: 1,9l R4 EDC 0000SG 1464
Coding: 00002
Shop #: WSC 00028
WVWZZZ3BZ2P302651 VWZ7Z0A4678350

3 Faults Found:
19466 - Relay for Fuel Cooling Pump (J445): Open or Short to Ground
P3010 - 35-10 - - - Intermittent
17978 - Engine Start Blocked by Immobilizer
P1570 - 35-00 - -
18261 - Powertrain Data Bus: Implausible Message from ABS Controller
P1853 - 35-10 - - - Intermittent
Readiness: 0 0 X X X

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 4B0-614-517.lbl
Part No: 4B0 614 517 G
Component: ABS/ESP front 1728
Coding: 00000
Shop #: WSC 00000

3 Faults Found:
18036 - Powertrain Data Bus: Missing Message from Steering Angle Sensor
P1628 - 35-10 - - - Intermittent
00778 - Steering Angle Sensor (G85)
66-10 - Not Matched - Intermittent
01044 - Control Module Incorrectly Coded
35-00 - -

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 3Bx-907-044.lbl
Part No: 3B1 907 044 H
Component: CLIMATRONIC B5GP 0008
Coding: 17000
Shop #: WSC 00028

5 Faults Found:
00603 - Footwell/defroster Flap Positioning Motor (V85)
35-10 - - - Intermittent
01272 - Positioning Motor for Central Flap (V70)
35-10 - - - Intermittent
01274 - Air Flow Flap Positioning Motor (V71)
35-10 - - - Intermittent
00532 - Supply Voltage B+
07-10 - Signal too Low - Intermittent
00792 - A/C Pressure Switch (F129)
35-10 - - - Intermittent

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 6Q0-909-605-VW5.lbl
Part No: 1C0 909 605 B
Component: 0A AIRBAG VW51 04 0004
Coding: 12353
Shop #: WSC 00028

1 Fault Found:
00588 - Airbag Igniter; Driver Side (N95)
32-10 - Resistance too High - Intermittent

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 3B0-920-xx5-17.lbl
Part No: 3B0 920 827 A
Component: KOMBI+WEGFAHRSP VDO V08
Coding: 05115
Shop #: WSC 30011
WVWZZZ3BZ2P902651 VWZ7Z0A4675380

2 Faults Found:
01128 - Immobilizer Pickup Coil (D2)
35-10 - - - Intermittent
01176 - Key
07-10 - Signal too Low - Intermittent

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901.lbl
Part No: 6N0 909 901
Component: Gateway K<->CAN 0001
Coding: 00006
Shop #: WSC 00028

2 Faults Found:
00778 - Steering Angle Sensor (G85)
49-10 - No Communications - Intermittent
01320 - Control Module for Climatronic (J255)
49-10 - No Communications - Intermittent

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1C0-959-799.lbl
Part No: 1C0 959 799 B
Component: 03 Komfortgerát HLO 0001
Coding: 00259
Shop #: WSC 00028

Part No: 1C1959801
Component: 03 Tõrsteuer.FS KLO 0004

Part No: 1C1959802
Component: 03 Tõrsteuer.BF KLO 0004

Part No: 1C0959811
Component: 03 Tõrsteuer.HL KLO 0004

Part No: 1C0959812
Component: 03 Tõrsteuer.HR KLO 0004

4 Faults Found:
01131 - Control Circuit for Turn Signals
25-10 - Unknown Switch Condition - Intermittent
01299 - Diagnostic Interface for Data Bus (J533)
49-10 - No Communications - Intermittent
01358 - Internal Central Locking Switch; Driver Side (E150)
27-10 - Implausible Signal - Intermittent
01359 - Internal Central Locking Switch; Passenger Side (E198)
27-10 - Implausible Signal - Intermittent

-------------------------------------------------------------------------------
Address 56: Radio Labels: 1J0-035-18x-56.lbl
Part No: 1J0 035 186 E
Component: Radio BNO 0006
Coding: 04403
Shop #: WSC 00028

2 Faults Found:
00852 - Loudspeaker(s); Front
36-10 - Open Circuit - Intermittent
00853 - Loudspeaker(s); Rear
36-00 - Open Circuit

posle kodiranja abs modula ostale su samo u abs sledece greska

Address 03: ABS Brakes
Control Module Part Number: 4B0 614 517 G
Component and/or Version: ABS/ESP front 1728
Software Coding: 04255
Work Shop Code: WSC 23456
3 Faults Found:

01486 - System Function Test Activated
35-00 - -
01542 - Yaw Rate Sensor (G202)
37-00 - Faulty
01542 - Yaw Rate Sensor (G202)
37-00 - Faulty

Potpis

Sale Knjazevac

Sada trebaš isti taj prekodirati samo moraš prvo da se logiraš tek onda da kodiraš procesor zatim napraviš adaptaciju senzora volana ako koristiš VCDS onda imaš helper koji će ti pomoći da završiš posao.Login dobijaš po opremi vozila.

ja sam se logovao i izvrsio kodiranje abs modula
onda sam kalibrisao ugao volana
a posle toga su mi se pojavile greske senzora spore brzine

Monday,04,January,2010,14:47:21:26365
VCDS Version: Release 805.0

Address 03: ABS Brakes
Control Module Part Number: 4B0 614 517 G
Component and/or Version: ABS/ESP front 1728
Software Coding: 04255
Work Shop Code: WSC 23456
3 Faults Found:

01486 - System Function Test Activated
35-00 - -
01542 - Yaw Rate Sensor (G202)
37-00 - Faulty
01542 - Yaw Rate Sensor (G202)
37-00 - Faulty

pozz

Sale Knjazevac

Potpis

Sale Knjazevac

Proveri ozicenje od tog senzora do abs modula nalaziti se senzor ispod zadnjeg sedista..a zna i on sam da nevalja takodje moze da se popravi..pozzzzz

Potpis

Pedja

instalacija proverena.
svi sest pina idu iz abs modula i nijedan nije u spoju ili premamasi.

naso sam drugi modul ali kod njega se gubi greska

01542 - Yaw Rate Sensor (G202) a pojavljuje se greska 01423 - Lateral Acceleration Sensor (G200)

moduli se razlikuju u zadnjem broju.
orginalni koji je bio na autu je 0 265 005 245
a ovaj drugi je sto sam imam 0 265 005 213

dali moze ovaj drugi senzor da radi na ovom autu

i zbog cega prijavljuje ovu drugu gresku.

Pozz

Sale Knjazevac

Potpis

Sale Knjazevac

Jel ti i taj od pasata, ja sam stavljao recimo na pasata od skode..taj nije isti pa vidi drugacije senzor po meni onaj modul koji ti je bio treba da je ok, ako si instalaciju proverio probaj zameni Yaw Rate Sensor...ako nemas drugi imas pp..pozzzzz

Potpis

Pedja

kod ovog starog je bio problem sto se zapalila instalacija abs pa je moguce da je prespojila bas prema modulu
zamenjen je ceo snop i sam abs i par puta sam proveravao instalaciju abs i sve je ok.

pozzzz

Sale Knjazevac

Potpis

Sale Knjazevac